Mercedes-Benz 211: fuses and relays
Content
The Mercedes-Benz 211 body is the third generation of E-class cars, which were produced in 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009 with gasoline and diesel engines (E200, E220, E230, E240, E270), E280, E300, E320, E350, E400, E420, E500, E55 and E63 AMG), as well as the w211 sedan and the S211 station wagon. During this time, the model has been redesigned. In this material, we will show the location of all electronic control units, a description of the fuses and relays of the Mercedes 211 with block diagrams and photo examples of their execution. Select the fuse for the cigarette lighter.
The location of the blocks and the purpose of the elements on them may differ from those shown and depend on the year of manufacture and the level of electrical equipment of your car.
Location
General arrangement of blocks
Description
one | ABS electronic control unit —> 31.05.06 |
two | ABS electronic control unit - 01.06.06^ |
3 | Antenna Amplifier - Audio/Navigation System |
4 | Aerial amplifier 1 (TV tuner) - rear window |
5 | Aerial Amplifier 2 (TV Tuner) - Left C-pillar (Saloon) - Left C-pillar (Pickup) |
6 | Aerial amplifier 3 (TV tuner) - right speaker C (sedan) - right speaker C (station wagon) |
7 | Crash sensor on the left behind the headlight |
eight | Crash sensor right behind the headlight |
nine | Side Impact Sensor Assembly, LH - B-pillar |
ten | Side impact sensor assembly, right side - B-pillar |
11 | Left trunk anti-theft control unit (integrated with multifunction control unit 2) |
12 | Anti-theft horn - behind wheel arch trim |
thirteen | Sunlight sensor - top center of windshield |
14 | Additional battery -> 31.05.06 if available |
fifteen | Additional battery -> 31.05.06 if available |
sixteen | Additional heating control unit |
17 | Auxiliary heater remote control receiver - right side of luggage compartment |
Eighteen | Battery - under the trunk floor |
nineteen | Battery control unit - trunk, bottom |
twenty | Trunk opening/closing control unit |
21 | CAN data bus, gateway control unit |
22 | Diagnostic connector (DLC) |
23 | Left front door control unit |
24 | Rear left door electric control box |
25 | Front right door electric control box |
26 | Rear right door electric control unit |
27 | Electronic engine control unit - diesel / 112/113 |
28 | Electronic engine control unit - 271 |
29 | Electronic engine control unit - 272/273 |
30 | Fuse / relay box, engine compartment |
31 | Fuse/Relay Box |
32 | Fuse/relay box in footwell |
33 | Fuse/Relay Box, Trunk |
3. 4 | Spare wheel fuse/relay box |
35 | Left headlight control unit (models with xenon headlights) |
36 | Right headlight control unit (models with xenon headlights) |
37 | Headlight range control unit - under the right front seat, under the carpet (models with xenon headlights) |
38 | Speaker 1 - Behind the bars |
39 | Horn 2 - behind the front bumper |
40 | Ignition lock control unit |
41 | Electronic immobilizer control unit (combined with ignition lock control unit) |
42 | Keyless entry system control unit - behind the ashtray |
43 | Lighting control unit - behind the headlight switch |
44 | Trunk Loading Control Unit (Van) - For Hollow Barrels |
Four five | Multifunction Control Module 1 - Connected to Engine Compartment Fuse/Relay Box - Functions: A/C Pressure Control, Brake Fluid Level, Coolant Level, Headlights, Headlight Washers, Horns, Interior Lights, Outside Temperature, Wiper Washer |
46 | Multifunction control unit 2 connected to fuse/relay box, trunk - Functions: anti-theft system, trunk/trunk lid release, central locking, fuel level, fuel pump, alarm, heated rear window, turn signals, rear lighting |
47 | Multifunction control unit 3 - in the multifunction switch control unit (overhead console) - functions: volume change sensors (anti-theft system), sunlight sensor, interior lighting sensor, rain sensor |
48 | Multi-function control unit 4-V multi-function switch control unit (dashboard) - functions: air conditioning control unit, central locking, alarm, rear wiper |
49 | Multifunction Control Unit 5" Multifunction Switch Control Unit (Center Console) - Functions: Auxiliary Heater Switch, Parking Assist, Active Suspension System, Tailgate/Trunk Lid Switch |
50 | Multifunction control unit 6 - Footwell, under carpet - Functions: Coolant pump motor, fog lights, heated seats, reversing lights, gear selector |
51 | Multifunction control unit 7 - in rear interior lighting (with transparent roof) - functions: interior lighting |
52 | Navigation system control unit |
53 | Room temperature sensor |
54 | Parking control module - left side of trunk |
55 | Rain sensor - top center of windshield |
56 | Power seat control unit, front left - under the seat |
57 | Power seat control unit, front right - under the seat |
58 | Header relay (06.01.05^) |
59 | Solar control unit - behind the instrument cluster |
60 | Steering column electric control unit - behind the steering wheel |
61 | Steering column lock control unit - built into the ignition lock control unit |
62 | Steering wheel position sensor - in the steering column electrical control unit |
63 | Heated steering wheel control unit - near instrument cluster (^05/05) |
64 | Power sunroof control box - in multifunction switch control box (overhead console) |
sixty five | SRS electronic control unit |
66 | Active Suspension Control Module - Footwell, Under Mat |
67 | Tailgate Open/Close Control Module - Left Side of Tailgate |
68 | telephone antenna |
69 | Telephone interface control unit - under the panel, in the rear of the trunk |
70 | Trailer Electrical Control Module - LH Trunk |
71 | Electronic transmission control unit (sequential manual transmission) - footwell, floor mat |
72 | ECM - footwell, floor mat |
73 | Tire pressure monitoring control unit - luggage compartment left side |
74 | Voice control unit - under the panel, in the rear of the trunk |
75 | Lateral motion sensor |
Block under the hood
Under the hood, the main fuse and relay box is located on the left side, next to the frame, and is covered by a protective cover.
scheme
designation
43 | 15A Control unit ME (engines 112, 113, 156, 271, 272, 273) |
CDI system control unit (engines 628, 629, 642, 646, 647, 648) | |
SAM control unit with rear relay and fuse box (engines 629, 642, 646, 647, 648) | |
SAM control unit with relay module and fuses on the driver's side (engines 629, 642) | |
44 | 15A CDI system control unit (engines 646, 647, 648) |
ME control unit (engines 271, 272, 273) | |
Gas supply valve cyl. 1 (engine 271 CNG) | |
Gas supply valve cyl. 2 (engine 271 CNG) | |
Gas supply valve cyl. 3 (engine 271 CNG) | |
Gas supply valve cyl. 4 (engine 271 CNG) | |
Four five | AIRmatic 7.5A control unit with ADS system |
Rear axle body level control unit | |
Selector Lever Electronic Module Control Unit (5-Speed Automatic Transmission (NAG)) | |
Selector lever position sensor (Sequentronic Semiautomatic (ASG)) | |
46 | 7.5A EGS control unit (5-speed automatic transmission (NAG)) |
Semi-automatic transmission control unit (Sequentronic (ASG)) | |
Electric control unit VGS (7-speed automatic transmission) | |
47 | 5A Control unit for ESP, PML and BAS systems |
48 | SRS control unit 7.5A |
Front left reversible seat belt pretensioner (2007 to present) | |
Reversible right front seat belt pretensioner (2007 to present) | |
49 | SRS control unit 7.5A |
Passenger/Child Seat Recognition Sensor, Front Passenger Seat | |
Headrest relay NECK-PRO | |
50 | Mobile phone circuit with 5A electrical connector |
VICS Power Off Point (Japan) | |
Emergency call system control unit (since 2007; USA) | |
51 | 5A Not used |
52 | Rotary switch outdoor lighting 7,5A |
Tool combination | |
Glove box lighting with microswitch | |
Headlight range control unit (bi-xenon headlights) | |
Engine and A/C intake fan with built-in regulator (since 2007) | |
53 place | Not used |
53б | 15A Horn relay |
54-th | 15A Illuminated cigarette lighter |
54б | 15A Illuminated cigarette lighter |
55 | Telephone 7,5A (standard telephone "MB") |
Bluetooth module plug connection (standard telephone "MB") | |
Mobile phone electrical connector circuit | |
Emergency call system control unit (since 2007; USA) | |
56 | Wiper motor 40A (M6/1) |
57 | 25A CDI system control unit (engines 628, 646, 647, 648) |
Suction electric fan for engine and air conditioner with built-in regulator (engines 271, 272, 273) | |
Me control unit (engines 271, 272, 273) | |
Reversing regeneration valve (engines 271, 272, 273) | |
PremAir system sensor (engines 271, 272, 273) | |
Vessel Stop Valve (USA) | |
58 | 15A Engines 112, 113, 156: |
Ignition coil 1 cylinder | |
Ignition coil 2 cylinder | |
Ignition coil 3 cylinder | |
Ignition coil 4 cylinder | |
Ignition coil 5 cylinder | |
Ignition coil 6 cylinder | |
Ignition coil 7 cylinder | |
Ignition coil 8 cylinder | |
59 | Starter relay 15/20A |
60 | 10A Oil cooler fan (E55 AMG, E63 AMG) |
61 | Electric air pump 40A |
62 | 30A ASG pump control relay (Sequentronic (ASG) semi-automatic transmission) |
63 | 15A Semi-automatic gearbox control unit (Sequentronic Semi-automatic Gearbox (ASG)) |
Terminal 87 relay, motor (motors 112, 113) | |
ME control unit (engines 112, 113) | |
64 | Rotary switch outdoor lighting 7,5A |
Tool combination | |
Steering column electronic module (until 2007) | |
UAC control panel | |
sixty five | Control unit 20A EZS |
Electric steering lock control unit | |
66 | 7,5A Right headlight |
Left headlight | |
Dial LWR (since 2007) | |
Headlight range adjustment module (bi-xenon headlights) | |
67 | Stoplight switch 5/10A |
Relay | |
Я | Terminal 87 relay, motor |
К | Relay, electrical terminal circuit 87 undercarriage |
Л | Starter relay |
METER | ASG pump control relay (until 2007) |
North | Relay terminal 15 |
OR | Horn relay |
П | Relay terminal 15R |
Р | Air pump relay (except engines 113.990 (E55 AMG), 156.983 (E63 AMG)) |
Oil cooler fan relay (engine 113.990 (E55 AMG), 156.983 (E63 AMG)) | |
Yes | AIRMATIC relay (semi-active air suspension) |
Т | Isolating relay for disconnected consumers (until 2007) |
Fuse number 54 is responsible for the front cigarette lighter, all other fuses are located in the trunk blocks.
Blocks in the salon
Block in the dashboard
On the left side of the instrument panel under the protective cover is the fuse box.
Photo - example
scheme
Goal
150A Power Supply: Rear Feed Fuse Box | |
21 | 25/30A Rear right door control unit |
22 | Right front door control unit |
23 | 30A Seat adjustment control unit with front passenger memory function |
24 | Wire terminal 25A Terminal 30, Keyless-Go |
25 | Auxiliary heater 25A protected by cable lug: (STH heater) |
5A Additional protection via auxiliary heater switch fuse: | |
Receiver unit for radio remote control of the auxiliary heater STH | |
26 | CD changer 7,5A |
27 | Relay 5A terminals 15 (since 2007) |
28 | Audio system 5A |
Control panel with display system COMAND (Japan) | |
Control panel for the audio module and navigation box 15A (Audio 50 APS) | |
Control panel 15A with COMAND system display | |
29 | 15A Electrical cable lugs 30 circuits |
15 A DC/DC converter control unit (until 2003) | |
Steering column electronic module El7.5 | |
Control unit 7,5A EZS | |
30 | Diagnostic connector 7,5 A |
31 | 5A Upper control box |
Separating relay 5A for disconnected consumers (2006) | |
SAM 7.5A control unit with relay module and driver's side fuses (until 2006) | |
32 | 25/30А Switchboard rear single-door left |
33 | 25/30A Left front door control unit |
3. 4 | 30A Driver seat adjustment control unit with memory function |
35 | 5A Passenger Weight System (WSS) control unit (since 2007; USA) |
36 | 25A Control unit for heated and ventilated seats |
37 | Control unit AIRmatic 7,5/15A with ADS system |
38 | Headrest relay 7.5A NECK-PRO |
39 | 5A Control box Lower control box |
40 | 5A Upper control unit (until 2006) |
10A Control unit for heated and ventilated seats | |
41 | 5A Central interface control unit |
42 | 7,5A Isolating relay for disconnected consumers (until 2006) |
ME control unit (engines 112, 113) | |
Terminal 87 relay, motor (motors: 629, 642, 646 EVO) | |
SAM control unit with relay module and driver side fuses (271, 272, 628, 629, 642, 646, 647, 648 engines) | |
CNG control unit (engine 271) |
Block under the dashboard
This fuse box is located in the front passenger footwell. To access it is necessary to remove the casing and protective cover.
scheme
transcribed
68 | Additional heater 200A (engines 629, 642, 646, 647, 648) |
69 | Glow 150A output stage (646, 647, 648 motors) |
150 A spark plug timeout (629, 642, 646 engines) | |
70 | Secondary Battery Relay 150A |
Starting the engine from an external power source (since 2007; type 211.2) | |
71 | A/C motor 100A and vacuum with integrated regulator (motors 112, 113, 156, 271, 272, 273, 629, 642, 646, 647, 648) |
72 | Hydraulic block SBC 50A |
73 | Hydraulic block SBC 40A |
40A ESP control unit (since 2007) | |
74 | Relay AIRMATIC 40A |
75 | 40A Passenger side SAM control unit |
76 | Catalyst purge relay 40A (2003; engines 113.990 (E55 AMG)) |
40A Reversible Right Front Pretensioner (PRE-SAFE) | |
77 | 40A Heater recirculation unit |
Solar generator control unit | |
Fan motor (since 2007) |
Blocks in the trunk
Block behind the upholstery
On the left side of the trunk, behind the trim, is a fuse and relay box.
scheme
Description
one | 30A Passenger side partially electric seat adjustment switch |
Driver's seat adjustment control unit with memory function | |
two | 30A Power seat partial adjustment switch, driver's side |
Seat adjustment control unit with front passenger memory function | |
3 | 7.5A RDK control unit (tire pressure monitoring system) |
PTS control unit (parktronic) | |
TV tuner (analog/digital) | |
Navigation processor | |
4 | Fuel pump 15/20A (except 113 990 (E55 AMG), 156 983 (E63 AMG)) |
Charge air cooler circulation pump 7,5/15A (113.990 (E55 AMG)) | |
5 | Not used |
6 | 40A Audio interface control unit |
Antenna amplifier module, left | |
Audio system | |
7 | 15A Rear door control unit |
eight | Antenna amplifier module 7,5A left |
Tilt sensor EDW | |
Sound alarm | |
nine | 25A roof control panel |
ten | Heated rear window 40A |
11 | 20A Rear door control unit |
12 | 15A socket in the trunk |
thirteen | 15A socket in the living room |
14 | Not used |
fifteen | 10A Fuel tank cap of the central locking drive |
sixteen | 20A Control unit for heated and ventilated seats |
17 | 20A AAG control unit (drawbar) |
Eighteen | 20A AAG control unit (drawbar) |
nineteen | 20A Air pump for multicontour seat |
twenty | 7.5A Rear window blind relay |
Relay | |
AN | Fuel pump relay (except engines 113.990 (E55 AMG), 156.983 (E63 AMG)) |
Charge air cooler circulation pump relay (only for engine 113.990 (E55 AMG)) | |
Б | Relay 2, terminal 15R |
С | Backup relay 2 |
Д | Rear Wiper Relay |
Me | Heated rear window relay |
Ф | Relay 1, terminal 15R |
GRAM | Fuel cap relay, polarity reversal 1 |
TIME | Gas cap relay, polarity switch 2 |
Block next to the battery
Another high power fuse box is installed next to the battery.
scheme
designation
78 | SAM 200A control unit with driver side fuse relay module |
79 | SAM 200A control unit with rear relay and fuse box |
80 | SAM 150A control unit with driver side fuse relay module |
81 | Internal fuse box 150A |
82 | 150A Fuse box II, rear right wheel arch (service vehicles) |
150A Fuse 82A and 82B (Engines 113.990 (E55 AMG), 156.983 (E63 AMG)) | |
82А | 30A Fuel pump relay (engine 113.990 (E55 AMG)) |
40A Fuse for the fuel pump control unit, left (engine 156.983 (E63 AMG)) | |
40A Fuel pump control unit fuse, right (engine 156.983 (E63 AMG)) | |
82B | Catalyst Purge Relay 40A |
83 | 30A Multifunction control unit Car Spec (MSS) (taxi) |
84 | 5A Battery control unit |
Battery sensor | |
85 | 5A telephone interface |
Hands-free system control unit | |
Voice Control Unit | |
UHI control unit (universal mobile phone interface) | |
86 | Interior socket (5A until 2003, 30A from 2004-2007, 5A from 2007) |
5A SDAR control unit (since 2007; USA) | |
30A Multifunctional control unit spec. Vehicles (MCS) (company cars, taxis) | |
30A GAS control unit (service vehicles) | |
30A Wire connector, terminal 30/inside (company vehicles) | |
87 | 40A air pump for dynamic seat adjustment |
88 | Control unit 30A HDS (type 211.0) |
Tailgate lock control unit (type 211.2) | |
89 | 40A Luggage compartment floor control unit (type 211.2) |
90 | 40A Front left reversible pretensioner (PRE-SAFE) |
Specifications of the multifunctional vehicle control unit (MCU) (taxi) | |
30A Fuel pump relay (up to 2004; engine 113.990 (E55 AMG)) | |
91 | 40A Multifunction control unit Car Spec (MSS) (taxi) |
That's all. And if you have something to add, write in the comments.