Fuses and relay Mercedes Ml164
Content
Mercedes ML W164 - the second generation of Mercedes-Benz M-class SUVs, which were produced in 2005, 2006, 2007, 2008, 2009, 2010, 2011 and 2012 with gasoline and diesel engines ML 280 CDI, ML 300, ML 320, ML 350 , ML 420, ML 450, ML 500, ML 550, ML 620, ML 63 AMG. During this time, the model has been redesigned. This information will also be useful to owners of the Mercedes GL X164 GL 320, GL 350, GL 420, GL 450 and GL 500 4MATIC, as these models have similar wiring diagrams. In this article, we will show the locations of electronic control units, a description of the fuses and relays of the Mercedes 164 with block diagrams, photo examples of their execution and location. Select the fuse for the cigarette lighter.
The location of the blocks and the purpose of the elements in them may differ from those presented and depend on the year of manufacture and the level of electrical equipment. Check the assignment with your diagrams, which are located near the fuse and relay boxes.
Circuit example
Location
Block layout
Description
one | ABS electronic control unit |
two | Air conditioning / heating control unit - in the air conditioning / heating control panel |
3 | Heater/A/C blower motor resistor - near blower motor |
4 | Sunlight Sensor (A/C)/Rain Sensor (Wipers) - Upper Center Windshield |
5 | Antenna Amplifier - Tailgate |
6 | SRS impact sensor, driver's side |
7 | Passenger Side SRS Crash Sensor |
eight | Side Impact Sensor, Driver's Side - Upper B-Pillar |
nine | Side impact sensor, passenger side - upper B-pillar |
ten | alarm siren |
11 | Audio Output Amplifier - Under Seat |
12 | Additional heater control unit - behind the wheel arch |
thirteen | Auxiliary heater control unit - under the left rear seat |
14 | Battery - under the seat |
fifteen | Remote control unit (cruise control) |
sixteen | CAN data bus, gateway control unit |
17 | Diagnostic connector (DLC) |
Eighteen | Differential Lock Control Unit - Hollow Barrels |
nineteen | Driver's door ECU - on the door |
twenty | Passenger door electric control unit in the door |
21 | ECM, V8 - Front footwell |
22 | Electronic engine control unit, V6 - top of the engine |
23 | Electronic engine control unit, Diesel - behind the wheel arch |
24 | Cooling fan motor control module - on cooling fan motor |
25 | Fuel pump control unit, left - under the rear seat |
26 | Fuel pump control unit, right - under the rear seat |
27 | Fuse / relay box, engine compartment 1 |
28 | Fuse / relay box, engine compartment 2 |
29 | Fuse/Relay Box, Instrument Panel |
30 | Fuse/Relay Box, Luggage Compartment - Behind Right Rear Trim |
31 | Under seat fuse/relay box |
32 | Left headlight control unit (xenon headlights) |
33 | Right headlight control unit (xenon headlights) |
3. 4 | Headlight range control unit - under the seat |
35 | Sound signal, lion. |
36 | Beep, right. |
37 | Ignition lock control unit |
38 | Instrument cluster control unit |
39 | Keyless entry control unit - right side of trunk |
40 | Multifunction control unit 1 - footwell - functions: central locking, power windows, fog lights, headlights, high beams, heated seats, heated washer jets, headlight washers, horn, turn signals, forward position, windshield wipers/washers |
41 | Multifunction Control Module 2" Cargo Compartment Fuse/Relay Box - Functions: Anti-Theft System, Central Locking (Rear), Rear Heater, Rear Wiper/Washer, Headlights (Rear), Turn Signals (Rear), Power Seat Relay (Passenger) ), brake lights, tailgate control unit, trailer electrical connector |
42 | Multifunction control box 3 - on multifunction switch (overhead console) - functions: Anti-theft system, garage door remote control, interior lighting, sunroof, rain sensor (wipers) |
43 | Navigation system control unit |
44 | Parking system control unit - under the seat |
Four five | Rear Seat Tilt Control Module - Under Left Rear Seat |
46 | Rear view camera control unit - under the seat |
47 | Driver's seat electronic control unit - under the seat |
48 | Passenger seat electronic control unit - under the seat |
49 | Seat heating control unit - under right rear seat |
50 | Seat occupant detection control unit - under the seat |
51 | Steering column electrical control unit - under the steering wheel |
52 | Electric sunroof control |
53 | SRS electronic control unit |
54 | Suspension control unit |
55 | Power tailgate - for hollow trunks |
56 | Telephone control unit - under the left rear seat |
57 | Transfer box control unit |
58 | Electronic transmission control unit - in the transmission |
59 | Electronic transmission control unit (DSG transmission) - in the transmission |
60 | Tire pressure monitoring control unit - in the fuse and relay box in the luggage compartment |
61 | Voice Control Unit - Under Left Rear Seat |
62 | Lateral motion sensor |
Fuse and relay boxes
scheme
designation
- F3 - Fuse box on the dashboard (passenger side)
- F4 - fuse and relay box in the trunk
- F32 - power fuse block in the engine compartment
- F33 - Fuse box in the battery niche
- F37 - AdBlue fuse block (for engine 642.820 from 1.7.09)
- F58 - Fuse and relay box in the engine compartment
Blocks under the hood
Fuse and relay box
This block is located on the right side under the hood.
scheme
Goal
100 | Wiper motor 30A |
101 | 15A Motor and A/C suction fan with built-in regulator |
Engines 156: Circuit terminal electrical cable terminals 87 M3e | |
113 Engines: Reversing regeneration valve | |
Engines 156, 272, 273: Reversing regeneration valve | |
Engines 272, 273: | |
Terminals of wires terminals of electrical circuits 87M1e | |
Suction fan control unit | |
629 Engines: | |
CDI system control unit | |
Cable terminal electrical terminals 30 circuits | |
Suction fan control unit | |
164 195 (hybrid ML 450): | |
ME control unit | |
Plug connection engine/engine compartment | |
642 engines except 642.820: | |
CDI system control unit | |
O2 sensor before catalytic converter | |
Suction fan control unit | |
Engines 642.820: O2 sensor before catalytic converter | |
102 | 15A Engines 642.820 up to 31.7.10: Gearbox oil cooler circulation pump |
156 Engines: Engine oil cooler circulation pump | |
10A 164,195 (hybrid ML 450): | |
Transmission oil cooler circulation pump | |
Coolant pump, low temperature circuit | |
103 | Electrical wire circuit terminals 25A 87M1e |
CDI system control unit | |
Until 2008; engines 113, 272, 273: ME control unit | |
20A 164.195 (ML 450 Hybrid): ME control unit | |
Engines 272, 273: ME control unit | |
104 | 15A Motors 156, 272, 273: Circuit terminal electrical cable terminals 87 M2e |
629 motors: Terminal 87 Wiring terminal circuits | |
Motors 642.820: Circuit terminal electrical cable terminals 87 D2 | |
Engines 642, except 642.820: CDI control unit | |
164 195 (hybrid ML 450): | |
Plug-in wiring harness for passenger compartment and engine | |
Engine compartment fuse and relay box | |
Engines 113: ME control unit | |
105 | 15A Engines 156, 272, 273: |
ME control unit | |
Electrical cable terminal circuit terminal 87 M1i | |
629 engines: CDI control unit | |
Engines 642.820: | |
CDI system control unit | |
Fuel pump relay | |
642 engines except 642.820: | |
CDI system control unit | |
Fuel pump relay (since 2009) | |
Starter (until 2008) | |
164.195 (ML 450 Hybrid): Plug connection for passenger compartment and engine wiring harness | |
Motors 113: Shielded circuit terminals 15 | |
106 | Not used |
107 | 40A Engines 156, 272 and 273: Electric air pump |
164.195 (ML 450 Hybrid): engine/engine compartment connector | |
108 | Compressor unit AIRmatic 40A |
109 | Switchboard ESP 25A |
164.195 (ML 450 Hybrid): Regenerative brake control unit | |
110 | 10A alarm siren |
111 | 30A Automatic transmission servo module for DIRECT SELECT system |
112 | 7,5A Left headlight |
Right headlight | |
113 | 15A left horn |
right horn | |
114 | 5A Before 2008: not used |
From 2009: SAM control unit, front | |
629 engines: CDI control unit | |
115 | Shield ESP 5A |
164.195 (ML 450 Hybrid): Regenerative brake control unit | |
116 | 7,5 A Electrical control module VGS |
164.195 (ML 450 Hybrid): Fully integrated gearbox control unit, hybrid | |
117 | Control unit Distronic 7.5A |
118 | 5A Engines 156, 272, 273: ME control unit |
Engines 629, 642: CDI control unit | |
119 | 5A Engines 642.820: CDI control unit |
120 | 10A Engines 156, 272, 273: |
ME control unit | |
Relay circuit terminal 87, motor | |
Engines 113: ME control unit | |
629 engines: CDI control unit | |
Engines 629, 642: Terminal 87 relay circuit, engine | |
121 | Heater STN 20A |
164.195 (ML 450 Hybrid): Fuse and relay box 2, engine compartment | |
122 | 25A Engines 156, 272, 273, 629, 642: Starting |
Engines 113, 272, 273: ME control unit | |
123 | 20A 642 Engines: fuel filter fogging sensor with heating element |
Engines 629, 642 from 1.9.08: Fuel filter fogging sensor with heating element | |
124 | 7.5A Model 164.120/122/822/825 from 1.6.09; 164.121/124/125/824: electro-hydraulic power steering |
164 195 (hybrid ML 450): | |
Electro-hydraulic power steering | |
Electric air conditioner compressor control unit | |
125 | 7.5A 164.195 (ML 450 Hybrid): Power electronics control unit |
Relay | |
AN | Wiper Mode Relay 1/2 |
Б | Wiper On/Off Relay |
С | 642 engines: additional circulation pump for transmission oil cooling |
Engines 156: Water circulation pump relay | |
Д | Relay circuit terminal 87, motor |
Me | Air pump relay |
Ф | Horn relay |
GRAM | Air suspension compressor relay |
TIME | Relay terminal 15 |
Я | Starter relay |
Power fuses
Located behind the fuse and relay box, behind the counter.
scheme
transcribed
- 4 - Not used
- 5 - 40A 164.195 (ML 450 Hybrid): Regenerative braking system control unit
- 6 - 40A ESP control unit, 80A - 164.195 (ML 450 Hybrid): Electro-hydraulic power steering
- 7 - 100A Suction electric fan for engine and air conditioner with built-in regulator
- 8 - 150 A Before 2008: Fuse and relay box in the engine compartment, 100 A From 2009: Fuse and relay box in the engine room
Blocks in the salon
Block in panel
It is located on the right side of the dashboard, behind a protective cover.
scheme
Description
ten | Electronic Amplifier Fan Controller 10A |
11 | Instrument panel 5A |
12 | 15A Control panel KLA (Deluxe automatic climate control system) |
Control panel KLA (luxury automatic climate control system) | |
thirteen | 5A Steering column electronic module |
Top unit control panel | |
14 | Control unit 7,5A EZS |
fifteen | 5A electronic compass |
multimedia interface control unit | |
sixteen | Not used |
17 | Not used |
Eighteen | Not used |
Block behind the battery
Under the passenger seat, on the right side, next to the battery, there is another fuse box.
scheme
designation
78 | 100A Before 30.06.09/XNUMX/XNUMX: Additional PTC heater |
150A Before 2008, from 1.7.09: PTC auxiliary heater | |
79 | 60A SAM control unit, rear |
80 | 60A SAM control unit, rear |
81 | 40A Engines 642.820: Relay for AdBlue supply |
150A From 1.7.09: Fuse and relay box in the engine compartment (except engines 642.820) | |
164.195 (ML 450 Hybrid): Vacuum pump relay (+) | |
Before 2008: not used | |
82 | 100 A fuse and relay box in trunk |
83 | 5A Passenger weight control unit (USA) |
84 | 10A SRS control unit |
85 | 25A From 2009: DC/AC converter control unit (115V socket) |
30A Before 2008: Automatic transmission servo module for "DIRECT SELECT" system | |
86 | Fuse box on the front panel 30A |
87 | 30A Transfer box control unit |
15A 164.195 (ML 450 Hybrid): Engine compartment fuse and relay box 2 | |
88 | 70A SAM control unit, front |
89 | 70A SAM control unit, front |
90 | 70A SAM control unit, front |
91 | 40A From 2009: Air conditioning recirculation unit |
Before 2008: fan controller |
Blocks in the trunk
Fuse and relay box
There is a box with fuses and relays in the trunk on the right side behind the interior trim.
scheme
Goal
twenty | 5A Before 2008: roof antenna module |
Since 2009: radio antenna noise filter | |
Since 2009: Microphone array control unit (Japan) | |
21 | Control unit 5A HBF |
22 | 5A PTS control unit (parking assistance) |
Receiver unit for radio remote control of the auxiliary heater STH | |
23 | DVD player 10A |
Rear Audio Control Unit | |
Wiring diagrams for mobile phones (Japan) | |
GSM network compensator 1800 | |
Bluetooth module | |
UHI control unit (universal mobile phone interface) | |
24 | 40A Right front seat belt recessive pretensioner |
25 | 15A Control and display unit COMAND |
26 | 25A Right front door control unit |
27 | 30A Seat adjustment control unit with front passenger memory function |
28 | 30A Driver's seat adjustment control unit with |
Memory | |
29 | 40A Front left recessive seat belt pretensioner |
30 | 40A From 2009: Rear bench seat control unit |
156 Engines: | |
Left fuel pump control unit | |
Right fuel pump control unit | |
164.195 (ML 450 Hybrid): terminal 30 electrical cable termination, fuel pump control unit | |
31 | 10A Control unit for heating, seat ventilation and steering wheel heating |
32 | Control unit AIRMATIC 15A |
33 | Keyless-Go system control unit 25A |
3. 4 | 25A Left front door control unit |
35 | Speaker amplifier 30A |
Since 2009: subwoofer amplifier | |
36 | 10A Emergency call system control unit |
37 | Rear view camera power module 5A (Japan) |
Rear view camera control unit (Japan) | |
38 | 10A digital TV tuner |
Before 2008: Audio Interface Control Unit (Japan) | |
Since 2009: Combined TV tuner (analogue/digital) (Japan) | |
164.195 (ML 450 Hybrid): high voltage battery module | |
39 | 7.5A RDK control unit (tire pressure monitoring system) |
Before 2008: SDAR control unit (USA) | |
From 2009: HD tuner control unit | |
Since 2009: Digital Audio Broadcasting Control Unit | |
Since 2009: detachable connection of the external part of the navigation system (South Korea) | |
40 | 40A Before 2008: Rear door lock control module |
30A From 2009: Tailgate lock control unit | |
41 | 25A roof control panel |
42 | 25A Before 2008: SHD engine |
From 2009: Roof control panel | |
43 | 20A Since 2009; Engines 272, 273: Fuel pump control unit |
Up to 31.05.2006/XNUMX/XNUMX: rear door wiper motor | |
As of 01.06.2006/XNUMX/XNUMX: Not used | |
44 | 20A Until 31.05.2006/2/XNUMX: Plug, XNUMXnd seat row, left |
Up to 31.05.2006/2/XNUMX: Power outlet XNUMXnd seat row, right | |
As of 01.06.2006/XNUMX/XNUMX: Not used | |
2009 onwards: Front Inner Plug (USA) | |
From 2009: 115 V socket | |
Four five | 20A socket in the trunk |
Before 2008: passenger compartment front fork | |
From 2009: socket in the second row on the right | |
46 | 15A Illuminated cigarette lighter, front |
47 | 10A 164.195 (ML 450 Hybrid) — High voltage battery coolant pump |
From 2009: door lighting | |
48 | 5A From 2009: Rear differential lock control unit |
Since 2009; Engines 642.820: AdBlue relay | |
From 1.7.09; for 164.195, 164.1 with engine 272 and 164.8 with engine 642 or 273: pyrotechnic igniter | |
49 | 30A rear window heating |
50 | 10A Before 31.05.2006/XNUMX/XNUMX: Rear door wiper motor |
15A From 01.06.2006/XNUMX/XNUMX: Rear door wiper motor | |
51 | 5A carbon cartridge check valve |
52 | 5A Before 31.05.09/XNUMX/XNUMX: Reversible front left seat belt pretensioner |
Before 31.05.09/XNUMX/XNUMX: Right front reversible seat belt pretensioner | |
From 2009: Rear differential lock control unit | |
53 | 5A AIRMATIC control unit |
156 Engines: | |
Left fuel pump control unit | |
Right fuel pump control unit | |
Engines 272, 273: Fuel pump control unit | |
From 2009: Transfer case control unit | |
54 | 5A Headlight range control unit (from 01.06.2006/XNUMX/XNUMX) |
SAM control unit, front | |
55 | 7.5A Instrument cluster |
Outdoor lighting with rotary switch | |
56 | 5A Before 31.05.2006/XNUMX/XNUMX: diagnostic socket |
Engines 642.820: AdBlue control unit | |
164.195 (ML 450 Hybrid): Fuel pump control unit | |
57 | 20A Before 2008: fuel pump with fuel level sensor |
Fuel pump (except engine 156) | |
58 | Diagnostic connector 7,5 A |
Central interface control unit | |
59 | 7.5AA from 2009: NECK-PRO headrest solenoid coil on the back of the driver's seat |
From 2009: NECK-PRO solenoid coil for headrest in backrest, front right | |
60 | 5A Glove box lighting with microswitch |
Engine compartment fuse and relay box | |
Rear SAM control unit | |
Mobile phone electrical connector circuit | |
Detachable power supply unit VICS+ETC (Japan) | |
Air pump for multicontour seat (since 2009) | |
Detachable connection of the external part of the navigation system (South Korea) | |
Blind spot monitoring, internal electrical outlet/rear bumper (since 1.8.10) | |
Emergency call system control unit (USA) | |
61 | 10A until 2008: |
Passive safety system control unit | |
Seat contact strip, front right | |
7.5A Since 2009: | |
Passive safety system control unit | |
Seat contact strip, front right | |
62 | 30A Passenger seat adjustment switch |
63 | 30A Driver's lumbar support control unit |
Front passenger's lumbar adjuster control unit | |
Driver seat adjustment switch | |
64 | Not used |
sixty five | Not used |
66 | 30A 2009 onwards: Air pump for multicontour seat |
67 | Air conditioner rear fan motor 25A |
68 | 25A Before 2008: 2nd row seat cushion heater, left |
Before 2008: 2nd row right seat cushion heating element | |
From 2009: Control unit for heating, seat ventilation and heated steering wheel | |
69 | 30A From 2009: Rear differential lock control unit |
70 | Drawbar connector AHV 20A, 13-pin (since 2009) |
Drawbar connector AHV, 7-pin | |
Drawbar connector AHV 15A, 13-pin (until 2008) | |
71 | 30A Plug connection Elektric-Brake-Control |
72 | Drawbar connector AHV 15 A, 13 pins |
Relay | |
К | Up to 31.05.2006/15/XNUMX: Terminal XNUMXR Relay socket, off-delay |
From 01.06.2006/15/XNUMX: Seat adjustment terminal XNUMXR | |
2009 onwards: Plug terminal circuit relay 15R (off delay) (F4kK) (electric seat adjustment) | |
Л | 30 times relay terminal |
METER | Heated rear window relay |
North | Relay terminal 15 circuit |
OR | Fuel pump relay |
П | Rear Wiper Relay |
Р | Relay terminal 15R |
Yes | Reserve 1 (changeover relay) (front output power supply) |
Т | From 01.06.2006/30/2: Take terminal XNUMX, XNUMXnd row of seats and trunk |
From 2009: Reserve 2 (NC relay) (power for outlets in center and rear) | |
You | From 01.06.2006/30/XNUMX: Relay terminal XNUMX circuit (trailer) |
В | From 01.06.2006/2/XNUMX: Reserve relay XNUMX |
Fuse number 46 at 15A is responsible for the operation of the cigarette lighter.
AdBlue system unit
Next to the AdBlue system is another fuse box responsible for its operation.
scheme
designation
- A - AdBlue 15A control unit
- B - AdBlue 20A control unit
- C - AdBlue 7.5A control unit
- D - not used