Replacing the fuel filter Hyundai Solaris

In this article, you will learn how to replace the Hyundai Solaris fuel filter. Traditionally for our site, the article is a step-by-step instruction and contains a large number of photo and video materials.

Our instructions are suitable for Hyundai Solaris cars with 1,4 1,6 liter engines, both first and second generation.

When should the fuel filter be changed?

The manufacturer has established a regulation: the fuel filter is replaced every 60 km. But in practice, it is better to change the filter more often, since the quality of fuel at Russian gas stations leaves much to be desired.

A clogged fuel filter manifests itself in the form of a lack of power, dips during acceleration, and a decrease in maximum speed.

If the fuel filter is not changed in time, problems may arise. Once Solaris came to our service with a faulty fuel pump, the cause of the breakdown was an avalanche of the network. Consequently, dirt got into the pump and it wore out, the cause of the mesh rupture was the formation of condensate in the tank and its freezing.

In practice, it is recommended to change the fuel filter every 3 years or every 40-000 km, whichever comes first.

If you live in big cities and drive a lot, the scheduled fuel filter change time is right for you.

What is required to replace the fuel filter?

Tools:

• neck with extension
• 8 bushing to unscrew the ring from the fuel module.
• sleeve 12 to unscrew the seat.
• clerical or ordinary knife for cutting sealant.
• clamp removal pliers.
• flat screwdriver to remove the fuel module.

Consumables:

• coarse mesh (31184-1R000 - original)
• fine filter (S3111-21R000 - original)
• sealant for gluing the lid (any, you can even Kazan)

The approximate cost of consumables is 1500 rubles.

How is the fuel filter replaced?

If you are too lazy to read, you can watch this video:

If you are used to reading, here is a step-by-step instruction with pictures:

Step 1: Remove the rear seat cushion.

To do this, unscrew the head by 12, the mounting bolt. It is located in the center and by moving up we raise the seat cushion, releasing the front supports.

Step 2: Remove the cover.

This is done with a clerical or ordinary knife, we cut the sealant and lift it.

Step 3 - Remove dirt.

This is necessary so that after dismantling the fuel module, all this dirt does not get into the tank. This can be done with a rag, brush or compressor.

Step 4 - Remove the fuel module.

Carefully disconnect all wires and break the fuel hose clamps. After that, we unscrew 8 bolts by 8, remove the retaining ring and carefully remove the fuel module.

Step 5 - Maintenance of the fuel module.

We replace the coarse filter (mesh at the inlet to the fuel pump), replace the fine filter - a plastic container.

ATTENTION! It is very important not to lose the O-rings when changing the filters.

A common mistake is losing the pressure regulator o-rings - if you forget to install the o-rings, the car won't start because no fuel is getting to the engine.

Step 6 - Reassemble everything in reverse order, glue the cover over the sealant, install the seat and enjoy the money saved.

To understand the degree of clogging of the fuel filter for 50 km of operation, you can see two photos (filter paper on one side and the other):

Conclusion.

I hope that after reading this article, you will understand that replacing the Hyundai Solaris fuel filter is not difficult.

Unfortunately, it is impossible to do this job without getting your hands dirty and not smelling gasoline, so it may make sense to turn to professionals.

With the help of the wonderful Repairman service, you can choose a car service near your home, study reviews about it and find out the price.

The average price of a fuel filter replacement service on Solaris for 2018 is 550 rubles, the average service time is 30 minutes.