Replacing the fuel filter Nissan Qashqai

Nissan Qashqai is a car loved by motorists around the world. Despite its reliability and durability, it is not so easy to care for it. Changing some parts with your own hands can be difficult. This fully applies to the fuel filter. However, with little experience, replacement is not particularly difficult. This must be done regularly; After all, the operation of the engine depends on the condition of the filter.

Nissan Qashqai is a compact crossover from a well-known Japanese manufacturer. Produced from 2006 to the present. During this time, with minor modifications, four models were released:

• Nissan Qashqai J10 1st generation (09.2006-02.2010);
• Nissan Qashqai J10 1st generation restyling (03.2010-11.2013);
• Nissan Qashqai J11 2st generation (11.2013-12.2019);
• Nissan Qashqai J11 2nd generation facelift (03.2017-present).

Also, from 2008 to 2014, a seven-seater Qashqai +2 was produced.

Filter replacement interval

The fuel filter passes fuel through itself, cleaning it from various impurities. The quality of the fuel mixture depends on the operation of this part, respectively, on the operation of the engine, its serviceability. Therefore, a lot depends on the timely replacement of the filter, it cannot be neglected.

According to the regulations, the fuel filter on a Nissan Qashqai diesel engine is replaced every 15-20 thousand kilometers. Or once every 1-2 years. And for a gasoline engine - every 45 thousand km. You should also pay attention to the following signs:

• the engine does not start properly and spontaneously stops;
• traction worsened;
• there are interruptions in the operation of the engine, the sound has changed.

These and other violations in the operation of the internal combustion engine may indicate that the filter element has ceased to perform its tasks. So it's time to change it.

It can fail prematurely if poor quality fuel or dirty injectors are used. Rust on the walls of the gas tank, deposits, etc. also lead to this.

Filter model selection

The choice does not depend on the generation of the car, Qashqai 1 or Qashqai 2, but on the type of engine. This car is available with petrol and diesel engines in various sizes.

For gasoline engines, the filter element is supplied with the pump from the factory, catalog number 17040JD00A. Ideal for replacing consumables with the number N1331054 manufactured by the Dutch company Nipparts. Its dimensions and characteristics are almost identical to the original spare part. Also fit FC-130S (JapanParts) or ASHIKA 30-01-130.

Qashqai diesel is equipped with an original part with the article number 16400JD50A. Can be replaced with Knecht/Mahle (KL 440/18 or KL 440/41), WK 9025 (MANN-FILTER), Fram P10535 or Ashika 30-01-122 filters.

Suitable solutions can also be found from other manufacturers. The main thing is the quality of the part and the complete coincidence of the dimensions with the original.

Preparing for replacement

To change the fuel filter with your own hands, you will need:

• Screwdriver Set;
• pliers with thin jaws;
• clean dry rags;
• hammer and saw for metal;
• new filter element.

Replacing the filter on Qashqai Jay 10 and Qashqai Jay 11 differs not depending on the model, but depending on the type of engine: gasoline or diesel. They are even located in completely different places and have fundamentally different designs. The petrol one is built into the fuel pump. The diesel filter is located in the tank, and the filter itself is in the engine compartment on the left side.

Therefore, to replace the filter element in the first case, it is necessary to remove the rear seats. Second, open the hood. In both cases, depressurization of the fuel line is required.

Replacing the fuel filter

How to change the fuel filter for Qashqai J10 and 11 (gasoline):

1. After removing the rear seat, unscrew the hatch with a screwdriver. There will be a fuel line hose and a feed connector.
2. Turn off the power, start the engine to burn off the remaining gasoline.
3. Drain excess gasoline from the tank, cover with a rag.
4. Press the release button on the fuel line clamp with a screwdriver to open it.
5. Unscrew the tank cap, remove the pump cup, disconnecting the wiring and hoses along the way.
6. Remove the lower part of the pump, which is attached with three latches. Remove the fuel gauge. Remove and clean the fuel pump strainer.
7. To disconnect the hoses from the filter, you need to cut a couple of fittings with a hacksaw and pick out the remnants of the hoses with needle nose pliers.
8. Replace new filter element and install in reverse order.

How to replace the fuel filter on Nissan Qashqai J 11 and 10 (Diesel):

1. Clean the outside of the fuel hoses from the fuel tank to the pump. Cut the clamps and disconnect the hoses from the filter.
2. Remove the clip located on the side of the frame.
3. By pulling up, disconnect the control valve together with the fuel hoses connected to it.
4. Loosen the bracket clamp, remove the filter.
5. Place the new filter in the bracket and tighten the clamp.
6. Moisten a new O-ring with fuel and install it.
7. Return the control valve and fuel hoses to their original position, fix them with clamps.
8. Engine starting. Give some gas to let the air out.

After replacing the Qashqai fuel filter, you should carefully inspect the system, especially the gaskets, to make sure it is tight.

Useful Tips

Also, when replacing with a Nissan Qashqai J11 and J10, you should pay attention to the following points:

1. Immediately after replacing the fuel pump, start the engine and let it idle for a few seconds. This will help the new filter element soak up the gasoline.
2. When replacing on a gasoline internal combustion engine, it is important not to break the float sensor by pulling on the pump. You must do this by tilting the part to be removed.
3. Before replacing a new diesel engine filter element, it must be filled with clean fuel. This will help to start the engine faster after replacement.

Conclusion

Changing the fuel filter for the first time (especially on petrol models) can be difficult. However, with experience this will happen without problems. The main thing is not to neglect the procedure, because not only the quality of the fuel mixture, but also the durability of the engine depends on it.