Oil change in automatic transmission Chevrolet Aveo T300

If you feel jerks or jerks when shifting gears from 1 to 2, from 3 to 4 speeds on a Chevrolet Aveo T300, this means it's time to change the oil in the automatic transmission. This car is equipped with an automatic transmission that is difficult to drain. After reading the article to the end, you will find out what the difficulty is. Although this difficulty was also encountered by those who had already independently changed the oil in the Aveo T 300 automatic transmission.

Write in the comments if you yourself changed the oil in the automatic transmission 6T30E?

Transmission oil change interval

This box was installed on front-wheel drive vehicles with an engine capacity of up to 2,4 liters. The manufacturer advises changing the oil in the automatic transmission of a car after a run of 150 kilometers. But this figure is taken from calculations under normal operating conditions.

Russian roads and weather are not normal conditions. And many novice drivers who do not know how to drive a car in the cold season, with an automatic instead of mechanics, make these conditions extreme.

In extreme conditions, it is recommended to change the oil every 70 km, carrying out a complete lubricant change. And I recommend a partial oil change after a run of 000 km.

Attention! Check the lubrication level in the Aveo T300 automatic transmission after a run of 10 kilometers. And along with the level, don't forget to look at the quality and color of the oil. If the oil in the automatic transmission has darkened, you see foreign impurities in it, then urgently change the lubricant in order to avoid breakdown of the Aveo T000 machine.

If you have not changed the oil and while driving you hear:

• noise in the automatic transmission;
• jerks and jerks;
• car vibration at idle

Full and partial do-it-yourself oil change in automatic transmission Polo Sedan

change the lubricant first. All these signs of bad oil should be gone. If they remain, take the car to a service center for diagnostics.

Practical advice on choosing oil in an automatic transmission Chevrolet Aveo T300

In the Chevrolet Aveo T300 automatic transmission, fill in only the original oil. The Aveo T300 is not as afraid of mixing liquids as dirty prey. A long trip in mining will clog the filter device, and the lubricant will no longer be able to perform its functions. The grease will overheat and heat up the mechanical parts. The latter will be subject to rapid wear.

Attention! When buying oil, do not forget about the filter device. It must be replaced along with the lubricant, otherwise it makes no sense to change the transmission fluid.

Original oil

Always use original oil when changing lubricant. For the Aveo T300 box, any Dexron VI standard oil is original. This is a fully synthetic fluid. For a partial replacement, 4,5 liters is enough, for a complete replacement, 8 liters.

Analogues

The following analogues are suitable for this gearbox if you cannot find the original oil in your city:

Read Idemitsu ATF automatic transmission oil: homologations, part numbers and specifications

• Havoline ATF Dexron VI;
• SK Dexron VI Corporation;
• XunDong ATF Dexron VI.

The manufacturer is strictly forbidden to use oils with a rate below that described.

Checking the level

Aveo T300 automatic transmission does not have a dipstick. Therefore, the usual way to check the level will not work. But for checking, a special hole is built into the box to check the oil level.

Another difference from other boxes is that the automatic transmission cannot be heated to 70 degrees. Otherwise, the grease will spill out more than it should. The steps to check the level are as follows:

1. Start a car.
2. Warm up the automatic transmission to 30 degrees. No more.
3. Place the Aveo T300 on a level surface.
4. With the engine running, get under the car and remove the plug from the check hole.
5. Place a drain pan under the spilled oil.
6. If the oil flows in a small stream or drips, then the level is sufficient. If the oil does not flow out at all, add about a liter.

Do not forget to control the quality of the lubricant. If it is black, replace the grease with a new one.

Materials for complex replacement in automatic transmission

Before you start replacing the Aveo T300 automatic transmission lubricant, you need to prepare all the materials and tools that you may need. Therefore, we are preparing the following materials:

• original grease or its equivalent with a tolerance of at least Dexron VI;
• filtering device with catalog number 213010A. These filters have a double membrane. Some manufacturers say they can easily work up to a complete fluid change. I wouldn't take his word for it if I didn't want my car to start in the middle of nowhere;
• crankcase gasket and plug seals (it is better to immediately buy a repair kit No. 213002);
• funnel and hose for filling new fluid;
• rag;
• a set of heads and keys;
• fat drain pan;
• Aveo T300 sump cleaner.

Read Full and partial oil change in automatic transmission Mazda 6

After everything is prepared, you can begin to change the lubricant yourself.

Write in the comments, did you change the Aveo automatic transmission lubricant with your own hands? How long did this process take you?

Self-changing oil in an automatic transmission Chevrolet Aveo T300

Now let's move on to the topic of replacement. Before driving into a pit or raising the car on a lift, you need to warm up the automatic transmission. But not to 70 degrees again. But only up to 30. The gear selector lever must be in the “P” position.

Draining old oil

To merge mining, follow these steps:

1. Unscrew the drain plug and replace the container.
2. Fat will begin to leave the system. Wait until the oil has completely drained into the container.
3. Remove the pallet by unscrewing the mounting bolts. Wear gloves because the oil may be hot.
4. Remove it carefully so as not to spill it on the exercise, as it can hold about 1 liter of liquid.
5. Drain the rest into a container.

Now we begin to wash the pan.

Pallet rinsing and swarf removal

Wash the inside of the Aveo T300 automatic transmission pan with a carb cleaner. Remove metal chips and dust from the magnets with a brush or cloth. A large number of chips should make you think about putting the automatic transmission in for repair. Perhaps some mechanical parts have already worn out and require urgent repair.

After washing the tray and cleaning the magnets, let these parts dry.

Read Repair automatic transmission Chevrolet Cruze

Filter replacement

Now unscrew the screws that hold the oil filter and remove it. Install a new one. Never wash the old filter. It will only worsen your performance.

In addition, this automatic transmission has a double membrane filter. If you don't want to mess with it, leave it until a full lube change. But I advise you to change the filter device after each oil change.

Filling in new oil

Automatic transmission Aveo T300 has a filler hole. It is located directly below the air filter. To get to it, you will need to remove the Aveo T300 air filter.

1. Install the tray and tighten the screws.
2. Change the seals on the plugs and tighten them.
3. After removing this filter, insert the hose into the hole at one end and insert a funnel into the other end of the hose.
4. Raise the funnel just above the level of the car's hood and start pouring in fresh grease.
5. You only need 4 liters. For this type of machine, it would be even better if there was underfilling and not overfilling.

Check the lubrication level in the Aveo T300 automatic transmission in the way that I wrote in the block above. Now you know how to do a partial oil change on an Aveo T300.

Write in the comments how you completely change the oil in the machine from the machine. Or take it to a service center?

Complete replacement of transmission fluid in automatic transmission

In general, a complete automatic transmission oil change in a Chevrolet Aveo T300 is similar to a partial fluid change. But with a difference. To carry out such a replacement, you will need a partner.

Attention! A complete change of mining is carried out at the service station using a special high-pressure apparatus. With it, old oil is pumped out and new oil is poured. This procedure is called the replacement process.

Procedure steps at home or on agar:

1. Repeat all steps to drain debris, empty pan and replace filter as above.
2. When you need to fill in new oil, fill it up and call your partner.
3. Disconnect the radiator return hose and put it on the neck of a five-liter bottle.
4. Have a partner start the Aveo T300 engine.
5. Waste oil is poured into a bottle. At first it will be black. It will then change color to light.
6. Shout to your partner to turn off the Aveo T300 engine.
7. Pour in all the oil that has drained into the bottle.
8. Now tighten the filler plug on the automatic transmission. Reinstall the filter device.

Do-it-yourself oil and filter change of automatic transmission Infiniti FX35

Drive the car and check the level again. Do not forget to carry out the procedure for adapting the automatic transmission to your driving style. This is to ensure that the vehicle does not move or push when pulling away or when changing gears. This often happens after pouring fresh fat.

Write in the comments if you have already done a complete oil change in the Aveo T300 automatic transmission?

Conclusion

Do not forget about changing the oil in the automatic transmission of the Aveo T300 car, about preventive work on the automatic transmission, which must be carried out every year. And, if the car is operated in extreme operating conditions, then twice a year. So the automatic transmission will last without repair, not only 100 thousand kilometers, but all 300 thousand.

If you liked the article, please like and share it on social networks. Write in the comments what else you would like to know about our site.